VICKERS柱塞泵工作原理： VICKERS柱塞泵是液壓系統的一個重要裝置。它依靠柱塞在缸體中往復運動，使密封工作容腔的容積發生變化來實現吸油、壓油。柱塞在缸體中要往復運動，因此，它的運動量很大，在工作過程中需要承受巨大的摩擦力，因此，柱塞要求高的硬度、耐磨性和使用壽命以及高的精度等。通過研究，采用淬火熱處理可以滿足柱塞的技術要求。
美國威格士柱塞泵的產品分類 1.軸向柱塞泵
軸向柱塞泵是活塞或柱塞的往復運動方向與缸體中心軸平行的柱塞泵。軸向柱塞泵是利用與傳動軸平行的柱塞在柱塞孔內往復運動所產生的容積變化來進行工作的。由于柱塞和柱塞孔都是圓形零件，加工時可以達到很高的精度配合，因此容積效率高，運轉平穩，流量均勻性好，噪聲低，工作壓力高等優點，但對液壓油的污染較敏感，結構較復雜，造價較高。
2.直軸斜盤式柱塞泵
直軸斜盤式柱塞泵分為壓力供油型的自吸油型兩種。壓力供油型液壓泵大都采用有氣壓的油箱，也有液壓泵本身帶有補油分泵向液壓泵進油口提供壓力油的。自吸油型液壓泵的自吸油能力很強，無需外力供油。靠氣壓供油的液壓油箱，在每次啟動機器后，必須等液壓漬箱達到使用氣壓后，才能操作機械。如液壓油箱的氣壓不足時就擔任機器，會對液壓泵內的與滑鞭造成拉脫現象，出會造成泵體內回程板與壓板的非正常磨損。
3.液壓柱塞泵
液壓柱塞泵靠氣壓供油的液壓油箱，在每次啟動機器后，必須等液壓漬箱達到使用氣壓后，才能操作機械。直軸斜盤式柱塞泵分為壓力供油型的自吸油型兩種。壓力供油型液壓泵大都采用有氣壓的油箱，也有液壓泵本身帶有補油分泵向液壓泵進油口提供壓力油的。自吸油型液壓泵的自吸油能力很強，無需外力供油。對于自吸油型柱塞泵，液壓油箱內的油液不得低于油標下限，要保持足夠數量的液壓油。液壓油的清潔度越高，液壓泵的使用壽命越長。
4.徑向柱塞泵
徑向柱塞泵可分為閥配流與軸配流兩大類。閥配流徑向柱塞泵存在故障率高、效率低等缺點。上70、80年代發展的軸配流徑向柱塞泵克服了閥配流徑向柱塞泵的不足。由于徑向泵結構上的特點，陜定了軸配流徑向柱塞泵比軸向柱塞泵耐沖擊、壽命長、控制精度高。變量行程短泵的變量是在變量柱塞和限位柱塞作用下，改變定子的偏心距實現的，而定于的zui大偏心距為 5—9mm（根據排量大小不同），變量行程很短。且變量機構設計為高壓操縱，由控制閥進行控制。故該泵的響應速度快。徑向結構設計克服了如軸向柱塞泵滑靴偏磨的問題。使其抗沖擊能力大幅度提高。 VICKERS變量柱塞泵，可以串聯齒輪泵。由齒輪泵與柱塞泵共同構成的油源系統，可以控制整體的功率曲線，使得恒功率控制不再局限于對單個油泵的控制，而是整個系統。 VICKERS變量柱塞泵工作狀態： VICKERS變量柱塞泵其吸入和排出閥都是單向閥。當柱塞外拉時，工作室內壓力降低，出口閥關閉，低于進口壓力時，進口閥打開，液體進入；柱塞內推時，工作室壓力升高，進口閥關閉，高于出口壓力時，出口閥打開，液體排出。 帶滑靴結構的軸向柱塞泵是目前使用zui廣泛的軸向柱塞泵，安放在缸體中的柱塞通過滑靴與斜盤相接觸，當傳動軸帶動缸體旋轉時，斜盤將柱塞從缸體中拉出或推回，完成吸排油過程。柱塞與缸孔組成的工作容腔中的油液通過配油盤分別與泵的吸、排油腔相通。變量機構用來改變斜盤的傾角，通過調節斜盤的傾角可改變泵的排量。 VICKERS變量柱塞泵柱塞往復運動總行程L是不變的，由凸輪的升程決定。柱塞每循環的供油量大小取決于供油行程,供油行程不受凸輪軸控制是可變的。供油開始時刻不隨供油行程的變化而變化。轉動柱塞可改變供油終了時刻，從而改變供油量。 美國威格士變量柱塞泵PVH系列: PVH057R02AA10AAB010A PVH057R02AA10A1400000010020001 PVH057R02AA10A2500000010010001 PVH057R02AA10A250000001001AB01 PVH057R02AA10A250000001001AE010A PVH057R01AA10A250000002001AE01 PVH057R01AA10A250000002001AB010A PVH057R01AA10A250000001AE1AB010A PVH057R01AA10A250000002001AB01 PVH057R01AA10A250000001001AE01 PVH057R01AA10A250000001AE10001 PVH057R01AA10A250000001AE1AB01 PVH057R01AA10A250000001AE1AE010A PVH057R01AA10H002000AW1AE1AB01 PVH057R01AA10B142000001AE1AB010A PVH057R01AA10B162000001AE1AC01 PVH057R01AA10B162000002001AF01 PVH057R01AA10B25000001001AE010A PVH057R01AA10B2520000010010001 PVH057R01AA10B252000001001AB01 PVH057R01AA10B252000001001AE01 PVH057R01AA10B252000001AE1AB01 PVH057R01AA10B252000001AN1AB010A PVH057R01AA10B252000002001AB01 PVH057R01AA10D250004001001AE01 PVH057R01AA10E252004001001AA010A PVH057R01AA10E252004001001AE01 PVH057R01AA10E252004001AE1AA010A PVH057R01AA10E252008001001AE010A PVH057R01AA10H002000AW1001AB010A PVH057R02AA10A250000001AE10001 PVH057R02AA10A250000002001AB01 PVH057R01AA10A250000001AN1AB010A PVH057R01AA10H002000AW2001AB01 PVH057R01AA50A250000001001AB01 PVH057R01AA50A250000001AE1AB01 PVH057R01AA50B252000001001AB01 PVH057R01AA50G002000AW1001AB000A PVH057R01AA50H002000AW1001AB010A PVH057R01AB10A250000002001AE010A PVH057R01AB10A250000002001AE010A PVH057R02AA10B162000001AE1AC01 PVH057R02AA10B25200000100100010A PVH057R02AA10B252000001001AA01 PVH057R02AA10B252000001001AB01 PVH057R02AA10B252000001002AB010A PVH057R02AA10B252000001AE10001 PVH057R02AA10B252000001AE1AA010A PVH057R02AA10B252000001AE1AB01 PVH057R02AA10B252000001AK100010A PVH057R02AA10B252000001AN10001 PVH057R02AA10B252000002001AA01 PVH057R02AA10H002000AW2001AB010A PVH057R02AB10B252000001001AA010A PVH057R0NAB10A250000002001AB01 PVH057R51AA10E252004001001AE010A PVH057R51AA10E252004001AE1AE010A PVH057R52AA10E252004001AE1AE010A PVH063R01AA10A230000001001AE010A PVH074L01AA10A2500000020010001 PVH074L01AA10B2520000010010001 PVH074L02AA10A00010A PVH074L02AA10AAA01 PVH074L02AA10A2500000010010001 PVH074L02AA10A250000001001AB01 PVH074L02AA10B252000001001AA01 PVH074L02AA10B252000001001AA010A PVH074L02AA10B252000001AF100010A PVH074L02AA10B252000001AF1AA010A PVH074L02AA10B252000AL1001AP01 PVH074L02AA10E252015001001AA01 PVH074L03AA10A250000001AF100010A PVH074L03AA10B252000001AF10001 PVH074L03AA10E252012001AF1AA010A PVH074L03AA50E252012001AF1AA010A PVH074L13AA10A250000001AF100010A PVH074L13AA10B202000001AL1AE010A PVH074L13AA10B202000001AL1AB010A PVH074R01AA10D250012001001AE010A PVH074R01AA10D250014001001AA01 PVH074R01AA10E212007001001AE010A PVH074R01AA10E252004001001AA010A PVH074R01AA10E252009001001AE01 PVH074R01AA10E252014001001AE01 PVH074R01AA10E252018001001AE010A PVH074R01AA10H002000AW1001AB01 PVH074R01AA10H002000AW2001AB01 PVH074R01AA50A250000001001AA010A PVH074R01AA50A250000001001AB01 PVH074R01AA50B252000001001AB01 PVH074R01AA50B252000001001AE01 PVH074R01AA50B252000002001AB01 PVH074R01AA50H002000AW1001AB010A PVH074R01AA60E252009001001AE01 PVH074R01AB10A25000000201AE010A PVH074R01AB10A250000002001AE010A PVH074R01AB10A250000002001AE010A PVH074R01AB50H002000AS1001AB01 PVH074R02AA10A2500000010010001 PVH074R02AA10A250000001001AB010A PVH074R02AA10A250000001001AE010A PVH074R02AA10A250000001AV1AE010A PVH074R02AA10A250000002001AE010A PVH074R02AA10B162000001001AC01 PVH074R02AA10B2520000010010001 PVH074R02AA10B252000001001AB01 PVH074R02AA10B2520000010020001 PVH074R02AA10B252000001AF100010A PVH074R02AA10B252000001AF1AA01 PVH074R01AA10AAB01 PVH074R01AA10AAC010A PVH074R01AA10AAB010A PVH074R01AA10A140000001001AC010A PVH074R01AA10A140000002001AF01 PVH074R01AA10A2500000010010001 PVH074R01AA10A250000001001AB010A PVH074R01AA10A250000001001AE01 PVH074R01AA10A250000001001AE010A PVH074R01AA10A250000002001AB010A PVH074R01AA10A250000002001AB010A PVH074R01AA10B162000001001AC01 PVH074R01AA10B162000002001AF01 PVH074R01AA10B2520000010010001 PVH074R01AA10B252000001001AB01 PVH074R01AA10B252000001001AE01 PVH074R01AA10B25200000200100010A PVH074R01AA10B252000002001AB01 PVH074R01AA10D250004001001AE01 PVH074R02AA10B2520000020010001 PVH074R02AA10B252000AL1002AP01 PVH074R02AA10H002000AW1001AB010A PVH074R03AA10A250000001AF100010A PVH074R03AA10A250000001AF1AB010A PVH074R03AA10B252000001AF1AB01 PVH074R03AA10B252000001AP1AA010A PVH074R0NAB10AAF01 PVH074R0NAB10A250000001001AE010A PVH074R0NAB10A250000002001AE01 PVH074R13AA10A140000001AF1AC010A PVH074R13AA10A160000001AF1AC01 PVH074R13AA10A250000001AF1AB01 PVH074R13AA10A250000001AF1AB010A PVH074R13AA10B252000001AF100010A PVH074R13AA10B162000001AF1AC01 PVH074R13AA10B252000001AF1AB01 PVH074R13AA10B252000001AF1AB010A PVH074R13AA10D200010001AF1AE010A PVH074R13AA10E252004001AF1AA01 PVH074R13AA10H002000AW1AF1AB01 PVH074R52AA10A25000000100100010A PVH081R01AA10AAC010A PVH081R01AA10A150000002001AC01 PVH081R01AA10A230000001001AE010A PVH098L01AJ30A25000000100100010A PVH098L01AJ30A2500000020010001 PVH098L01AJ30A250000002001AB01 PVH098L01AJ30B2520000010010001 PVH098R01AJ30A140000002001AF01 PVH098R01AJ30A2500000010010001 PVH098R01AJ30B162000002001AF010A PVH098R01AJ30B2520000010010001 PVH098R01AJ30B252000001001AA010A PVH098R01AJ30B252000001001AB010A PVH098R01AJ30B25200000100200010A PVH098R01AJ30B252000001001AB010A PVH098R01AJ30B252000002001AB01 PVH098R01AJ30D250004001001AE010A PVH098R01AJ30D250010001001AE010A PVH098R01AJ30E252009001001AE01 PVH098R01AJ30E252015001001AE01 PVH098R01AJ30A250000001001AB01 PVH098R01AJ30E252020001001AE010A PVH098R01AJ30H002000AW1001AB01 PVH098R01AJ30H002000AW2001AB010A PVH098R01AJ70A250000001001AB01 PVH098R01AJ70A250000001001AB010A PVH098R01AJ70A250000002001AB010A PVH098R01AJ70B252000001001AB010A PVH098R01AJ70B252000001001AE01 PVH098R01AJ70E252004001001AE01 PVH098R01AJ70H002000AW1001AB010A PVH098R01AJ30A250000001001AB010A PVH098R01AJ30A250000001001AR010A PVH098R01AJ30A250000001003AB010A PVH098R01AJ30A250000001001AB010A PVH098R01AJ30A2500000020010001 PVH098R01AJ30A250000002001AB010A PVH098R01AJ30A250000002001AB010A PVH098R02AJ30AAB010A PVH098R02AJ30AAE010A PVH098R02AJ30A2500000010010001 PVH098R02AJ30A250000001001AB01 PVH098R02AJ30A2500000020010001 PVH098R02AJ30B25200000100100010A PVH098R02AJ30B252000001001AA01 PVH098R02AJ30B252000001001AB01 PVH098R02AJ30B252000001001AP010A PVH098L01AJ30B252000001001AB01 PVH098L02AJ30A25000000100100010A PVH098L02AJ30A250000001002AA010A PVH098L02AJ30B172000001AD20001 PVH098L02AJ30B25200000100100010A PVH098L02AJ30B252000001001AA010A PVH098L02AJ30B252000001001AP010A PVH098L02AJ30B25200000100200010A PVH098L02AJ30B252000001AD10001 PVH098L02AJ30B2520000020010001 PVH098L02AJ30B252000AL1001AP01 PVH098L02AJ30E252015001001AA010A PVH098L03AJ30A250000001AD1AA01 PVH098L03AJ30B252000001AD10001 PVH098L03AJ30B252000001AD1AP010A PVH098L03AJ30B252000001AM10001 PVH098L03AJ30B252000AL1AD2AP01 PVH098L13AJ30E252004001AD1AA01 PVH098L53AJ30B252000001AD2AA010A PVH098QIC RSF 1S 10 C25 31 PVH098R01AD30A250000001001AB01 PVH098R01AD30A250000001001AB010A PVH098R01AD30A250000001001AE010A PVH098R01AD30A250000002001AB010A PVH098R01AD70B172000002001AB010A PVH098R01AJ30AAB010A PVH098R01AJ30AAB010A PVH098R01AJ30AAB01 PVH098R02AJ30B252000001AD100010A PVH098R02AJ30B2520000020010001 PVH098R02AJ30B252000002001AB010A PVH098R02AJ30E252004001001AA010A PVH098R02AJ30E252004001001AE01 PVH098R02AJ30H002000AW1001AB010A PVH098R02AJ30H002000AW2001AB010A PVH098R03AJ30A250000001AD100010A PVH098R03AJ30B252000001AD10001 PVH098R03AJ30B252000001AD1AB01 PVH098R03AJ30B252000AL1AD1AP01 PVH098R13AJ30A070000001AD1AB01 PVH098R13AJ30A250000001AD1AB01 PVH098R13AJ30A250000002001AE010A PVH098R13AJ30B162000001AD1AC010A PVH098R13AJ30B252000001AD100010A PVH098R13AJ30B252000001AD1AB01 PVH098R13AJ30E252004001AD1AA010A PVH098R13AJ30E252004001AD1AE01 PVH098R13AJ30E252004001AD1AE010A PVH098R13AJ30E252010001AD1AE01 PVH098R13AJ30E252018001AD1AE01 PVH098R13AJ30H002000AW1AD1AB01 PVH098R13AJ70B252000001AD1AE01 PVH106R01AJ30A230000001001AE010A PVH106R02AJ30A230000001001AE010A PVH106R13AJ70D230007001AC1AA010A PVH106R13AJ70D230010001AC1AA010A PVH131 PVH131L 02 322304 PVH131R13AF30A250000001001AB01 PVH131R13AF30A25000000100100010A PVH131R13AF30B25200000100100010A PVH131R13AF30B252000001001AB01 PVH131R13AF30B252000001001AB010A PVH131R13AF30B252000001001AE010A PVH131R13AF30B252000002001AB010A PVH131R13AF30D250007001001AE010A PVH131R13AF30E252004001001AA01 PVH131R13AF30E252008001001AE01 PVH131R13AF30E252015001001AE010A PVH131R13AF30H002000BD2001AB01 PVH131R13AF70B2520000010010001 PVH131R13AF70B252000001001AE01 PVH131R13AF70E252018001001AA01 PVH131R03AF30A250000001001AB010A PVH131R03AF30B2520000010010001 PVH131R03AF30B252000001AD10001 PVH131R03AF30B252000001AD1AP01 PVH131R03AF30B252000009AD1AP010A PVH131R03AF30H002000BD2002AB010A 此版權信息屬于上海維特銳，欲了解更多相關產品，請點擊：VICKERS 柱塞泵 |
點擊放大
